1. This site uses cookies. By continuing to use this site, you are agreeing to our use of cookies. Learn More.

Suzuki Every Runs Great, but dies after warmed up

Discussion in 'Microvans' started by MadMax, May 10, 2024.

  1. MadMax

    MadMax New Member

    I have a 1996 Suzuki Every Joypop, Fuel injected, Turbo, 2wd, Automatic. DE51V. It starts and runs great until it is warmed up, then it stalls and won't start again until it cools down. When it is in the non running state, it appears to have spark and fuel. I am suspecting a vacuum leak some where. Also after this happens I am getting a beeping from under the dash. It is 2 quick beeps, repeating. Anyone deal with this?
  2. t_g_farrell

    t_g_farrell Active Member

    Sounds like a choke issue. Its a EFI setup so not sure how the choke works on that. Did you just get it or did it run fine and then this started happening? Not much detail to go on yet.
  3. MadMax

    MadMax New Member

    Thanks but fuel injected vehicles do not have chokes.
  4. t_g_farrell

    t_g_farrell Active Member

    Ok, not a choke but its working ok when cold but then falls down when hot. Check sensors for the EFI (TPS, etc)
  5. JHDD51

    JHDD51 New Member

    Running into the same problem with my 96 Domingo, once its warmed up (about 15-20 min into driving) it will loose power, I can drive it home but only in 2/3rd gear and at above 4500 RPM.

    Plugs good, filter good, pump good, now to check any sensors and maybe clean the injectors.

    I live at 6300' so maybe its something to do with the altitude change. Since it will run after ding at high RPM the engine must not be getting enough air? Also since these vans have been at sea level their whole lives
  6. t_g_farrell

    t_g_farrell Active Member

    You can't assume all of Japan is at sea level, its fairly mountainous actually. For EFI I would start with all the sensors first.

Share This Page